You might also hear ongoing whirring noises, or noises that change or get louder if you increase the fan speed. These are all signs of problems with the blower motor. In some cases, you may even notice smoke or smells of burning while driving, in which case you should pull over immediately.
What happens when your blower motor goes out?
WEAK AIRFLOW OF THE BLOWER MOTOR The fans will work at certain speeds until they stop working altogether. Such a fault not only results in poor airflow but also decreases the efficiency of the defroster as it uses the same fan to blow air at the windshield.
How do you tell if it's the blower motor or resistor is bad?
Signs of a Bad Blower Motor Resistor Loss of HVAC fan control (total or certain speeds) The fan only works on its highest speed setting. No air coming from vents. Intermittent or inconsistent fan speed.
What happens when your blower motor goes out?
WEAK AIRFLOW OF THE BLOWER MOTOR The fans will work at certain speeds until they stop working altogether. Such a fault not only results in poor airflow but also decreases the efficiency of the defroster as it uses the same fan to blow air at the windshield.
How much should it cost to replace a blower motor?
Replacing a blower motor costs $450 on average with a typical range of $250 to $800. With a warranty, you might pay as little as $150 for labor alone. For high-end models, like those with large motors or access issues, you might pay as much as $2,000.
What causes a blower motor to fail in a car?
In most cases, a blower motor resistor fails due to corrosion or overheating. Sometimes, the mechanical resistance to the motor rotation causes an excessive electric current that can overheat and prematurely damage the blower motor resistor.
Is there a fuse for blower motor?
What happens when a blower motor relay goes bad?
If the blower motor relay develops any sort of problem that hinders its ability to properly limit and distribute power, it may cause the blower motor fuse to blow. Any sort of electrical spikes or excessive current from a bad relay will blow the fuse and cut power in order to protect the system.
What happens when a blower motor resistor fails?
If the resistor shorts or fails, it may cause the blower motor to remain stuck on one fan speed. The heating and air conditioning systems may still function at one speed, however the resistor will have to be replaced in order for full functionality to be restored.
Can you drive with a bad blower motor?
Should you drive with a bad heater blower motor? A bad heater blower motor will not affect the safety of your car, with the possible exception of you not being able to clear the windshield of snow, ice, or condensation if the defrosters don't work.
What happens when a blower motor relay goes bad?
If the blower motor relay develops any sort of problem that hinders its ability to properly limit and distribute power, it may cause the blower motor fuse to blow. Any sort of electrical spikes or excessive current from a bad relay will blow the fuse and cut power in order to protect the system.
How long does it take to replace a blower motor in a car?
How Long Does It Take To Replace A Blower Motor In A Car? It generally takes about 4 hours for an experienced technician to do a blower motor replacement. If you are doing it on your own in your garage with common tools, you can expect the job to take 6 hours or more.
What happens when blower motor resistor goes out?
If the resistor shorts or fails, it may cause the blower motor to remain stuck on one fan speed. The heating and air conditioning systems may still function at one speed, however the resistor will have to be replaced in order for full functionality to be restored.
Is it hard to replace a blower motor?
The replacement of the blower motor is common and straightforward, so most shops will perform the repair — many on the same day.
What happens when your blower motor goes out?
WEAK AIRFLOW OF THE BLOWER MOTOR The fans will work at certain speeds until they stop working altogether. Such a fault not only results in poor airflow but also decreases the efficiency of the defroster as it uses the same fan to blow air at the windshield.
How long does it take to replace a blower motor in a car?
How Long Does It Take To Replace A Blower Motor In A Car? It generally takes about 4 hours for an experienced technician to do a blower motor replacement. If you are doing it on your own in your garage with common tools, you can expect the job to take 6 hours or more.
How long do blower motors last in a car?
The blower is supposed to last the entire lifetime of your car. However, situations vary and some climates require the fan to be used too often. Many car owners find themselves having to replace the blower after five years. The quality of the motor used to power the blower matters.
How many blower motors are in a car?
The number of blower motors in your vehicle depends on its climate control system. Some cars have one blower motor, but that may not be the case for some SUVs and vans. They may have two motors, one in the heater box and another in the vehicle's rear area.
Is it hard to replace a blower motor?
The replacement of the blower motor is common and straightforward, so most shops will perform the repair — many on the same day.
Where is a blower motor located?
The blower motor is usually under the dashboard on the passenger side. Blower motors that make loud squeaks or rattling noises may be worn out and on the verge of packing it in, but sometimes those noises are caused by leaves or other debris that can be cleaned out after the motor is removed from the vehicle.
Can a blower motor be repaired?
There are a number of things that can go wrong with your heating system, but if the air stops blowing altogether and the same is true on cold air settings, a blower motor replacement is likely in order. The good news is that it's a fairly straight forward repair.
When should I replace my blower motor?
If the motor is making rattling, clanking, or banging sounds, it may be because of a loose or broken part. Loud banging sounds are especially worrisome. They're usually a sign that something is damaged or disconnected. And this may mean replacing the blower motor.
Why is my car not blowing any air?
Here are some of the most common causes of why air doesn't flow out of your vehicle's vents: Your air intake is clogged, meaning that air isn't getting in from the outside at all or isn't circulating properly. There is a blown fuse in the ventilation system. Electrical issues such as a bad relay.
Where is the fuse for the fan blower?
Under the instrument panel, look under the glove box. On the right side of the fender wall you will find another fuse box.
What causes heater blower not working?
If little air is coming through the vents (hot or cold), then it could be because the blower motor for the fan or a switch or resistor that controls fan speed isn't working. Another cause might be that the electronically controlled “blend doors” that direct air flow are stuck or broken.
How much does it cost to replace a blower motor relay?
The blower motor is operated by an electrically operated switch, called a relay. If the relay fails, the motor's fans will not blow conditioned air into your car. Fixing the relay usually costs around $50 to $80. So, if the blower motor relay fails, you could be left sweating or shivering.
How do I know if my blower motor resistor is bad?
No air from the vehicle’s vents Another symptom of a faulty blower motor resistor is no air from the vehicle’s vents at all. Power to the blower motor is fed through the blower motor resistor, so if it fails or has any issues power can be cut off to the motor.
How do I know if my air conditioner blower is bad?
Inspect your air filters. Lots of times, airflow restriction from a dirty filter will cause a blower motor to overheat. The excess heat in the motor will cause its performance to degrade, and the motor may fail altogether. If your blower has a fan belt, take a loot at it. If the belt is snapped, then the blower won’t work.
What are the symptoms of a bad furnace blower motor?
There are 5 main bad furnace blower motor symptoms to look for: Weak airflow coming from the vents. Weak airflow can be an indicator of other problems too such as used up air filters but problems with the motor are a likely cause too.
What happens if a blower motor is not working?
Power to the blower motor is fed through the blower motor resistor, so if it fails or has any issues power can be cut off to the motor. A blower motor without power will not be able to produce any air pressure, and as a result the heating and air conditioning system will be left with no air coming from the vents.
Below you will find two interesting articles on a similar topic 👇
How do you fix a car heater that blows cold air?Why is the blower in my car not working?
