How Long Does It Take To Replace A Blower Motor In A Car? It generally takes about 4 hours for an experienced technician to do a blower motor replacement. If you are doing it on your own in your garage with common tools, you can expect the job to take 6 hours or more.
Is a blower motor a hard to replace car?
The replacement of the blower motor is common and straightforward, so most shops will perform the repair — many on the same day.
How long does it take to replace a AC blower motor?
An experienced HVAC technician will take about 30 minutes to remove the old blower motor and about and 60 minutes to install the new motor, adjust it, if it's a multi or variable speed motor, and test run the furnace. Installing a new blower wheel or cleaning the old wheel will only take a few additional minutes.
How much does it cost to replace the blower motor in a car?
How can I tell if my blower motor is bad in my car?
You might also hear ongoing whirring noises, or noises that change or get louder if you increase the fan speed. These are all signs of problems with the blower motor. In some cases, you may even notice smoke or smells of burning while driving, in which case you should pull over immediately.
How long do blower motors last?
What happens when blower motor goes bad?
If the blower motor is completely bad, then you'll have no airflow at all. Strange sounds coming from blower. Blower motors can make all kinds of sounds, depending on what the issue is. Vibrations, grinding, and high pitched-noises are some of the sounds a blower can make if it's going bad.
What causes blower motor failure?
Blower motor breakdown can be the result of anything from old age to failed bearings, high amp draw, electrical failure in the windings, dirt accumulation, and more. “The most common cause is dirt accumulation due to lack of maintenance,” said Tom Beaulieu, president of Bay Area Services Inc.
How much does it cost to replace a blower motor on an AC unit?
If you suspect your AC blower motor has gone bad, you probably want to know what the cost to fix it will be. Replacing an air conditioner blower motor in Florida can cost anywhere from $499 to $1875. More specifically, your exact blower motor replacement cost depends on the following factors: Motor speed.
Can you drive a car without a blower motor?
Your car's blower motor is not only necessary for the operation of your air conditioner. Without a functioning blower motor your engine runs the risk of overheating.
How many blower motors are in a car?
The number of blower motors in your vehicle depends on its climate control system. Some cars have one blower motor, but that may not be the case for some SUVs and vans. They may have two motors, one in the heater box and another in the vehicle's rear area.
Why is my blower motor so loud in my car?
Loud noises you hear when your car's heater or air conditioner are on typically indicate a blower motor issue. The good news is that a blower motor problem like this can be the result of something as simple to fix as debris or trash that got caught in it.
What is the difference between a fan motor and a blower motor?
What Is a Blower Motor? Unlike the condenser fan motor, the blower motor is located indoors. It's the component that blows cool air through the ducts and into different parts of your home. So it's essentially your air mover.
When should I replace my blower motor?
If the motor is making rattling, clanking, or banging sounds, it may be because of a loose or broken part. Loud banging sounds are especially worrisome. They're usually a sign that something is damaged or disconnected. And this may mean replacing the blower motor.
How much does it cost to replace blower motor resistor?
How much does a blower motor resistor cost? To replace the blower motor resistor, it would cost you anywhere between $50 to$150 – this includes the cost of equipment and labor. However, by doing it yourself at home, you can save up to $70.
What does a bad blower motor sound like?
A defective blower motor will make a continuous sound noticeable by the passengers in the vehicle. It can manifest as a knocking, whirring, clunking, vibrating, squealing, or whining noise that persists until the blower motor is replaced.
Can a bad blower motor cause no AC?
Power to the blower motor is fed through the blower motor resistor, so if it fails or has any issues power can be cut off to the motor. A blower motor without power will not be able to produce any air pressure, and as a result the heating and air conditioning system will be left with no air coming from the vents.
How do you tell if it's the blower motor or resistor is bad?
Signs of a Bad Blower Motor Resistor Loss of HVAC fan control (total or certain speeds) The fan only works on its highest speed setting. No air coming from vents. Intermittent or inconsistent fan speed.
Can a blower motor be repaired?
There are a number of things that can go wrong with your heating system, but if the air stops blowing altogether and the same is true on cold air settings, a blower motor replacement is likely in order. The good news is that it's a fairly straight forward repair.
Where is a blower motor located?
The blower motor is usually under the dashboard on the passenger side. Blower motors that make loud squeaks or rattling noises may be worn out and on the verge of packing it in, but sometimes those noises are caused by leaves or other debris that can be cleaned out after the motor is removed from the vehicle.
How much does it cost for a blower motor?
Furnace Blower Motor Replacement Cost On average nationwide, a furnace blower motor replacement costs $400 to $600, including parts and labor. A single-speed blower motor costs around $450 to replace while a variable-speed motor costs $600 or more. You'll also need to budget labor, about $75 to $125 per hour.
Why do I have to hit my blower motor to work?
Blower motor only start working after i hit a bump. In most cases that is a sign of worn down blower motor brushes not making a good contact. In some cases the blower motor/resistor pigtail could cause erratic operation of the blower motor too.
What are possible causes when a blower makes a noise?
However, a loud bang, rattling, squealing, and slapping sounds can be an indication that there is something wrong with the blower. The root cause can be loose motor mounts, an object caught in the blades, and a weak belt.
What causes blower motor failure?
Blower motor breakdown can be the result of anything from old age to failed bearings, high amp draw, electrical failure in the windings, dirt accumulation, and more. “The most common cause is dirt accumulation due to lack of maintenance,” said Tom Beaulieu, president of Bay Area Services Inc.
Can a bad blower motor cause no heat?
Problems with Your Blower Motor or Blower Motor Resistor Without it, there's no circulation of air—hot, cold, or otherwise. The blower motor resistor is the part that controls the fan speed of the blower motor. Both of these components can fail, resulting in the heating system simply not working.
What causes a blower motor resistor to burn out?
In most cases, a blower motor resistor fails due to corrosion or overheating. Sometimes, the mechanical resistance to the motor rotation causes an excessive electric current that can overheat and prematurely damage the blower motor resistor.
How much does it cost to replace a blower motor?
The average cost of a blower motor replacement can fall between $340 and $400. Labor alone for a blower motor replacement can cost up to $300. Of course, these figures are approximate. You will have to visit a mechanic so that he or she can look at your vehicle and give you an exact value. Where is the Blower Motor Located?
How long does a car heater blower motor last?
When you need heat in a hurry in your car’s cabin, the blower motor will have to spring into action. For the most part, the heater blower motor on your car is supposed to last as long as the actual vehicle does. Due to the harsh conditions that this blower motor has to operate in, it will usually end up having repair issues.
Does a blower motor heat or cool the air?
While a blower motor doesn't heat or cool the air, it is a critical component of your car's ability to do so, as it's responsible for pushing the heated or cooled air through the vehicle's HVAC vents. The most common sign of a failed blower motor is an air conditioning and heating system that doesn't respond to the HVAC controls.
What is a blower motor on a car?
Your vehicle’s blower motor is the car component that forces air throughout the vehicle’s vents. So, when it fails to work, it’s time to replace it. Thanks to the blower motor, you’re able to regulate the speed of the motor. Whether you use buttons, switches or dials on your dash, you have complete control.
Below you will find two interesting articles on a similar topic 👇
How often should a blower wheel be cleaned?What does blower motor relay do in car?
