A blower motor turns the fan in your HVAC unit, which causes the outgoing air to circulate out of the system and into the rooms of your home. The blower motor is the part of your HVAC system that gets your home to the temperature set on your thermostat.The blower motor is the central component of the air conditioning system, responsible for blowing hot or cold air through the AC vents in a car. If the blower motor stops working due to a fault, the air will not flow out of the vents when you switch on the AC in your vehicle. A mouse nest in the fan blower motor cage.
How much does it cost to replace a blower in an AC unit?
Replacing the blower motor in an AC unit costs the same as a furnace since they share this mechanism. Expect to pay $250 to $800 on average. You might spend up to $2,000 depending on the brand.
What happens when a blower motor goes bad?
The blades of the fan are made of plastic and they can get damaged easily. If it happens, you will hear unusual noises like slapping or sudden pop coming from behind the vent. Problems with the airflow have signs such as ongoing whirring, getting louder when you increase the fan speed.
Where is the blower motor on AC unit?
The blower motor sits inside the “air handler”, otherwise known as the indoor unit (see below).
How long should an AC blower motor last?
The average lifespan of an AC fan motor is about 12 years. An AC fan motor can last more than 12 years if it's kept clean and cooled as needed. On the other hand, without annual maintenance checkups, your fan motor may only survive between one and three years.
Can a bad blower motor cause no AC?
Power to the blower motor is fed through the blower motor resistor, so if it fails or has any issues power can be cut off to the motor. A blower motor without power will not be able to produce any air pressure, and as a result the heating and air conditioning system will be left with no air coming from the vents.
How long does it take to replace a blower motor?
How long does it take to replace a blower motor? Replacing a blower motor takes 2 to 3 hours on average. The blower motor is typically located behind a control board and other furnace parts.
Why is my AC blower not working?
In air conditioning mode, check the indoor unit for ice around the evaporator coil and refrigerant lines. If the fan is not working, the coil could freeze. With a frozen coil, air will not pass through until the ice melts. You should shut off the air conditioning immediately.
Can a blower motor be repaired?
There are a number of things that can go wrong with your heating system, but if the air stops blowing altogether and the same is true on cold air settings, a blower motor replacement is likely in order. The good news is that it's a fairly straight forward repair.
How often do blower motors go out?
How much is an AC blower fan?
Whether you're looking at a furnace blower or an AC blower, both have the same average cost of $250 to $800. This is because it's the same part that carries out both functions. Whether you chill out without central air, or you have both heating and AC, you'll only have one blower motor to worry about.
What causes AC blower to stop working?
If the fan stops turning, air will stop moving through the system. A number of things could cause this to happen, from tripped circuit breakers to a faulty thermostat. However, it is also possible that the blower motor has stopped working. Typically, blower motors have a very long life.
How much does it cost to replace a car AC blower motor?
How much does it cost to replace a blower motor resistor?
How much does a blower motor resistor cost? To replace the blower motor resistor, it would cost you anywhere between $50 to$150 – this includes the cost of equipment and labor. However, by doing it yourself at home, you can save up to $70.
Can you run the AC without a blower?
To avoid this, it may be best to leave the fan on. Running your heating and cooling fan even when the AC isn't on helps circulate air throughout your home for consistent comfort. And with the air being circulated by the fan, you'll often end up with cleaner, fresher air in your home.
Is my blower motor going out?
If the blower motor is completely bad, then you'll have no airflow at all. Strange sounds coming from blower. Blower motors can make all kinds of sounds, depending on what the issue is. Vibrations, grinding, and high pitched-noises are some of the sounds a blower can make if it's going bad.
How hard is it to change a blower motor?
The replacement of the blower motor is common and straightforward, so most shops will perform the repair — many on the same day.
What causes blower motor failure?
In most cases, a blower motor resistor fails due to corrosion or overheating. Sometimes, the mechanical resistance to the motor rotation causes an excessive electric current that can overheat and prematurely damage the blower motor resistor.
Where is the blower reset button?
Locate the reset button on the furnace and press it to reset the furnace. It is usually located inside the blower compartment on the side of the blower motor. Be cautious as the housing may be hot. If the button is popped up, press it down.
Where is the AC reset button?
Look for it first around on the exterior of your machine, especially along the bottom edge near the ground. An AC's reset button is typically red and visible, so it should be easy to spot. If you don't see a reset button on the outside, it could be located inside the unit behind the service panel.
Is a blower motor covered under warranty?
What is covered under warranty? The warranty only covers functional parts such as: blower motor, compressor, coil, control board, heat exchanger, etc.
How long does it take to replace a condenser fan motor?
A professional HVAC technician can replace a condenser fan motor in one to two hours, though most technicians will also conduct an inspection and potentially replace other parts at the same time, meaning a full repair may take longer.
How much does it cost to replace a blower motor?
How much does it cost to replace a blower motor resistor?
How much does a blower motor resistor cost? To replace the blower motor resistor, it would cost you anywhere between $50 to$150 – this includes the cost of equipment and labor. However, by doing it yourself at home, you can save up to $70.
Is there a fuse for the blower motor?
Can you run the AC without a blower?
To avoid this, it may be best to leave the fan on. Running your heating and cooling fan even when the AC isn't on helps circulate air throughout your home for consistent comfort. And with the air being circulated by the fan, you'll often end up with cleaner, fresher air in your home.
What is an air conditioner blower motor?
As explained in the HVAC Blower Motor Guide, an air conditioner blower motor and assembly is basically the fan inside the air conditioning system that forces the cooled air, via the AC cooling coil, through the vents and into the room space that is being conditioned.
How do I know if my air conditioner blower motor is bad?
If you turn on your air conditioning system and find that there is no air blowing out of the AC unit, or no buzz of the blower fan motor, then it is possible the AC blower motor has an issue. This is one of the most common and easy ways to know if your air conditioner blower motor is broken or not.
How does a blower motor work on a furnace?
Air heating systems such as electric and gas furnaces, air conditioners, heat pumps, and mini splits all utilize a blower motor to transfer this air. Anytime your thermostat communicates to your heating or cooling system that the temperature settings are not being met, your system will kick on.
What is an AC fan motor and how does it work?
What is an AC Fan Motor? The fan motor is a fairly uncomplicated yet vital part of an air conditioner. It’s the part of the unit that pumps air through the system. Without that circulation of air, your AC won’t cool your home.
Below you will find two interesting articles on a similar topic 👇
Where is my home AC blower motor located?How much is a fan motor for an air conditioner?
