The blower motor resistor is usually extremely easy to access, but the hard part can be positioning your body inside the car to remove the part. The resistor is at the bottom of the HVAC housing or just behind the glove compartment.The resistor is about 2 inches x 3 inches and is installed in a hole in the plenum (duct) near the blower motor. It will have a wiring harness connected to it. It could be under the passenger dash or under the hood, depending on where the blower motor is.
Where is the fan blower resistor?
It's located inside the dash, often on the opposite side of the steering wheel or inside the engine compartment on the firewall. A blower motor resistor or a blower motor control module is the part that controls the speed of the blower motor.
How do I know if it's the blower motor or the resistor?
Typically, if the fan will work on some speeds but not on others, the resistor is suspect. Okay, let's say there's no melting going on, but your fan doesn't work on all speeds. Typically, if the fan will work on some speeds but not on others, the resistor is suspect.
What happens when a blower motor resistor fails?
If the resistor shorts or fails, it may cause the blower motor to remain stuck on one fan speed. The heating and air conditioning systems may still function at one speed, however the resistor will have to be replaced in order for full functionality to be restored.
Where is the fan blower resistor?
It's located inside the dash, often on the opposite side of the steering wheel or inside the engine compartment on the firewall. A blower motor resistor or a blower motor control module is the part that controls the speed of the blower motor.
Is it easy to replace a blower motor resistor?
How to Replace a Blower Motor Resistor. The blower motor resistor is usually extremely easy to access, but the hard part can be positioning your body inside the car to remove the part. The resistor is at the bottom of the HVAC housing or just behind the glove compartment.
How do you remove and replace a blower motor resistor?
Locate the blower motor resistor on the passenger side under the dash board. It is mounted to the the blower housing near the blower motor. Disconnect the electrical connector to the blower motor resistor. Remove the screws or bolts to the blower motor resistor and remove the resistor.
Should you replace blower motor and resistor at the same time?
We do suggest that you replace the resistor at the same time. It may not be critical, but this will keep the system more uniform. The issue may even be related to the resistor. If you know that it is not related to the issue, then you do not have to replace it.
Is there a fuse for blower motor?
How much does it cost to replace blower motor resistor?
How much does a blower motor resistor cost? To replace the blower motor resistor, it would cost you anywhere between $50 to$150 – this includes the cost of equipment and labor. However, by doing it yourself at home, you can save up to $70.
How do I know if my blower motor relay is bad?
If you have a faulty blower motor, you may experience low airflow from the vents, even when the fan is on high. There will be no air coming from the vents if your fan isn't working due to a bad blower motor resistor. Blown relay circuit fuses or melted relays are more serious signs of a bad blower motor relay.
How much does it cost to replace blower motor resistor?
How much does a blower motor resistor cost? To replace the blower motor resistor, it would cost you anywhere between $50 to$150 – this includes the cost of equipment and labor. However, by doing it yourself at home, you can save up to $70.
Where is a blower motor located?
The blower motor is usually under the dashboard on the passenger side. Blower motors that make loud squeaks or rattling noises may be worn out and on the verge of packing it in, but sometimes those noises are caused by leaves or other debris that can be cleaned out after the motor is removed from the vehicle.
Where is AC resistor located?
It is located in the heater and air conditioning compartment. It's connected to the air conditioning system, where it can adjust the speed of the blower motor fan. It can also be found behind the glove box of some vehicles. Either way, you will find it close to the blower motor.
Where is the fan blower resistor?
It's located inside the dash, often on the opposite side of the steering wheel or inside the engine compartment on the firewall. A blower motor resistor or a blower motor control module is the part that controls the speed of the blower motor.
What causes a heater fan to stop working?
If little air is coming through the vents (hot or cold), then it could be because the blower motor for the fan or a switch or resistor that controls fan speed isn't working. Another cause might be that the electronically controlled “blend doors” that direct air flow are stuck or broken.
What happens when blower motor goes bad?
If the blower motor is completely bad, then you'll have no airflow at all. Strange sounds coming from blower. Blower motors can make all kinds of sounds, depending on what the issue is. Vibrations, grinding, and high pitched-noises are some of the sounds a blower can make if it's going bad.
Where is the blower motor fuse located?
Many vehicles have two fuses for the blower motor, one in the interior fuse block and the other under the hood. The blower motor is usually under the dashboard on the passenger side.
What causes blower motor failure?
Blower motor breakdown can be the result of anything from old age to failed bearings, high amp draw, electrical failure in the windings, dirt accumulation, and more. “The most common cause is dirt accumulation due to lack of maintenance,” said Tom Beaulieu, president of Bay Area Services Inc.
Where is a blower motor located?
One of the hardest-working parts of your home's furnace is the blower motor. In a gas forced air furnace, it's located in a box at the base of the furnace next to the air filter, where it draws return air through the filter.
What relay controls the blower motor?
In a blower motor, the relay supplies the power that allows the fans to circulate warmed air. Essentially an on/off switch, the blower motor relay's reactions start and end the heating process in HVAC systems by controlling the flow of current between the power source and the motor.
Can I run my car without a blower motor?
Your car's blower motor is not only necessary for the operation of your air conditioner. Without a functioning blower motor your engine runs the risk of overheating.
Should I replace the blower motor and resistor at same time?
We do suggest that you replace the resistor at the same time. It may not be critical, but this will keep the system more uniform. The issue may even be related to the resistor. If you know that it is not related to the issue, then you do not have to replace it.
Is there a fuse for blower motor?
What does a fan resistor do?
Blower resistors are resistors which are used to control the fan speed of automotive blowers. The fan speed can be changed either by switching the blower resistor resistance mechanically using a rotating lever, or electronically by the air conditioning system.
What causes blower motor failure?
Blower motor breakdown can be the result of anything from old age to failed bearings, high amp draw, electrical failure in the windings, dirt accumulation, and more. “The most common cause is dirt accumulation due to lack of maintenance,” said Tom Beaulieu, president of Bay Area Services Inc.
Where is the blower motor resistor located?
Blower motor resistor. It's located inside the dash, often on the opposite side of the steering wheel or inside the engine compartment on the firewall. In most modern cars, the speed of the blower motor can be adjusted gradually. The electronic module that controls the speed of the blower motor is called a blower motor control module.
Can a blower motor resistor cause a fan to stop working?
In some cars, a failed blower motor resistor can cause a heater fan to stop working completely. In most cases, a blower motor resistor fails due to corrosion or overheating. for example, when the fan blade is jammed by foreign objects or when the motor bearings are worn out.
Where is the blower motor resistor on a 2008 Ford F150?
In the 2008-2011 Ford F150, the blower motor resistor is also located behind the glove box, but is installed on the right side of the plastic air duct. This thread at f150online.com shows where the resistor is located.
What part controls the speed of the blower motor?
A blower motor resistor or a blower motor control module is the part that controls the speed of the blower motor. How the speed of the blower motor is controlled. See also:
Below you will find two interesting articles on a similar topic 👇
How much does it cost to replace blower motor resistor?Why won’t my furnace blower fan turn on?
